2002 Product Recalls
669 recalls issued in 2002.
Showing 141–160 of 669 recalls
Electric Fans Recalled for Fire Hazard
These electric fans have undersized wiring, use a power plug that is not polarized, overheat and have an improperly sized grill, all of which could cause electrocution, electric shock, fire, and finger entrapment hazards to consumers.
Consumers should stop using these electric fans immediately and return them to the store where purchased for a full refund. Consumers can also return the fans to the firm for a full refund, by mailing the unit to: 110 West Graham Ave., Hempstead, N.Y., 11550.
ARVINMERITOR/PRO-FUEL AND NAPA FUEL FILTERS
PROLONGED EXPOSURE CAN RESULT IN THE DEGRADATION AND WEAKENING OF THE REGULATOR DIAPHRAGM. AS A RESULT, THE DIAPHRAGM MAY LEAK FUEL, POSSIBLY RESULTING IN A VEHICLE FIRE.
ARVINMERITOR WILL NOTIFY ITS CUSTOMERS AND REPLACE THE SUSPECT FUEL REGULATORS. OWNER NOTIFICATION BEGAN OCTOBER 1, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ARVINMERITOR LVA CUSTOMER SERVICE AT 800-637-0580.
TOYOTA/REAR BRAKE LINE
IF THIS CONDITION OCCURS FREQUENTLY, THE REAR BRAKE LINE COULD BE DAMAGED, WHICH COULD RESULT IN LEAKAGE OF BRAKE FLUID, CAUSING A DECREASE IN BRAKE EFFECTIVENESS.
DEALERS WILL REPLACE THE REAR BRAKE LINES. OWNER NOTIFICATION BEGAN NOVEMBER 9, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
GM/BATTERY CABLE
IF THE CABLE STRANDS CONTACTED THE EXHAUST PIPE A SHORT CIRCUIT COULD CAUSE THE BATTERY CABLE COATINGS TO IGNITE AND POSSIBLY LEAD TO AN ENGINE COMPARTMENT FIRE.
DEALERS WILL INSPECT THE BATTERY CABLE FOR PROPER ROUTING AND REROUTE THE CABLE IF NECESSARY. OWNER NOTIFICATION BEGAN OCTOBER 25, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
HARLEY-DAVIDSON/CLUTCH CABLE
THE LOSS OF REAR BRAKE FLUID COULD CAUSE THE LOSS OF REAR BRAKE FUNCTION, POSSIBLY WITHOUT WARNING AND COULD CAUSE A CRASH.
DEALERS WILL REPLACE THE BRAIDED CLUTCH CABLE. OWNER NOTIFICATION BEGAN OCTOBER 21, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HARLEY-DAVIDSON AT 1-414-342-4680.
FLEETWOOD/REFRIGERATOR WIRING
THIS COULD CAUSE A FIRE.
DEALERS WILL INSPECT, REPLACE OR REPAIR DAMAGED 110 VOLT AND 12 VOLT WIRES AS NECESSARY. OWNER NOTIFICATION BEGAN OCTOBER 11, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FLEETWOOD AT 1-800-322-8216.
BUELL/SIDE STAND LEGS
THIS COULD CAUSE THE MOTORCYCLE TO FALL INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SIDE STAND. OWNER NOTIFICATION BEGAN OCTOBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUELL AT 1-414-342-4680.
MACK/FMVSS 121/PARKING BRAKE PERFORMANCE
DEALERS WILL MODIFY THE PARK BRAKE CONFIGURATION ON THESE VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MACK AT 1-610-709-3337.
FORD/BRAKE AND ACCELERATOR PEDAL DISTANCE
THIS COULD RESULT IN A CUSTOMER EXPERIENCING AN "UNINTENDED VEHICLE SPEED INCREASE" OR A PERCEIVED "UNABLE TO STOP" CONDITION.
OWNERS WILL BE INSTRUCTED AS TO THE PROPER WAY TO SET THE POSITION OF THE PEDALS AND TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE SPACING BETWEEN THE BRAKE AND ACCELERATOR PEDALS MEASURED. IF THE SPACING IS FOUND TO BE LESS THAN 50 MM, THE DEALER WILL ADJUST THE PEDALS TO INCREASE THE DISTANCE BETWEEN THEM TO GREATER THAN 50 MM. OWNER NOTIFICATION BEGAN OCTOBER 28, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Siebe actuators Recalled for Fire Hazard
A spring mechanism integrated with the damper is designed to close the damper during a fire to limit the spread of smoke, fire and fumes. The recalled actuators can jam and prevent the dampers from closing. If dampers fail to close during a fire, serious injury or death can be suffered by building occupants because smoke, fire and fumes can spread through a building's ventilation system.
To be eligible for a free actuator replacement, the building owner must test the actuator and report the results to Invensys. Only actuators that fail testing will be replaced.
Siebe actuators Recalled for Fire Hazard
A spring mechanism integrated with the damper, is designed to close the damper during a fire to limit the spread of smoke, fire and fumes. The recalled actuators can jam and prevent the dampers from closing. If dampers fail to close during a fire, serious injury or death can be suffered by building occupants because smoke, fire and fumes can spread through a building's ventilation system.
To be eligible for a free actuator replacement, the building owner must test the actuator and report the results to Invensys. Only actuators that fail testing will be replaced.
Performance Forte Pro Stix Bar Ends (Bicycle Handlebar Recalled for Injury Hazard
The bar ends can crack when tightened and come loose during use, which can cause riders to lose control of the bicycle and possibly suffer injuries.
Consumers should stop using the bar ends immediately and return them for a replacement or refund. Consumers can return the bar ends to the nearest Performance Store or by mailing them to Performance Inc., Attn: Returns Dept., One Performance Way, Chapel Hill, NC 27514.
Four-wheel drive All Terrain Vehicles (2002 Model Year) Recalled for Fire Hazard
The hose barbs that are used for the fuel fittings on the bottom of the fuel tank may have been overly tightened and possibly the wrong sealer was used during assembly. This can cause the threaded joint to fail and the sealer to not adhere to the joint itself. Fuel can drip from the tank, posing a fire hazard. In addition, there was a casting flaw in the aluminum housing on the front suspension. This could cause the front wheel to come loose from the connection point, causing the rider to lose control of the vehicle.
Consumers should stop using these ATVs immediately and contact their local Manco Products, Inc. dealer to schedule a free repair or to receive a full refund. Owners of these ATVs have been directly notified about this recall.
Glass Candleholder Recalled for Laceration Hazard
The candleholder can unexpectedly shatter and cause cuts to consumers.
Firm no longer in business. Recall remedy no longer available. Discard the product.
HARNESS UV PROTECTION
IF THE WEBBING IS EXPOSED TO SIGNIFICANT AMOUNTS OF SUNLIGHT, IT COULD DEGRADE. IF THE WEBBING STRENGTH DEGRADES MORE THAN ALLOWED BY THE STANDARD IT MAY NOT PROVIDE SUFFICIENT PROTECTION TO A CHILD IN A CRASH, CAUSING AN INCREASED RISK OF INJURY TO THE CHILD.
DJG'S PETITION FOR RELIEF FROM REMEDY BASED ON ITS BELIEF THAT THE NONCOMPLIANCE WAS INCONSEQUENTIAL TO MOTOR VEHICLE SAFETY WAS DENIED BY NHTSA ON JANUARY 5, 2010. ACCORDINGLY, DJG WILL CONDUCT A SAFETY RECALL CAMPAIGN. IT WILL NOTIFY REGISTERED OWNERS AND PROVIDE FREE REPLACEMENT KITS FOR THE HARNESSES ALONG WITH REPAIR INSTRUCTIONS. THE SAFETY RECALL BEGAN ON FEBRUARY 16, 2010. OWNERS MAY CALL DJG TOLL-FREE AT 1-866-690-2539.
THULE/BIKE RACK
SHOULD THIS OCCURS WHILE THE VEHICLE IS IN MOTION, A FOLLOWING MOTORIST COULD STRIKE THE BIKE(S), POSSIBLY RESULTING IN A VEHICLE CRASH.
THULE WILL NOTIFY ITS DEALERS AND CUSTOMERS AND WILL REPLACE THE DEFECTIVE BIKE RACKS FREE OF CHARGE. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING SEPTEMBER 2002. OWNERS WHO DO NOT RECEIVE THE FREE REPLACEMENT BIKE RACK WITHIN A REASONABLE TIME SHOULD CONTACT THULE AT 800-848-5391.
THULE/BIKE RACK
SHOULD THIS OCCUR WHILE THE VEHICLE IS IN MOTION, A FOLLOWING MOTORIST COULD STRIKE THE BIKE(S), POSSIBLY RESULTING IN A VEHICLE CRASH.
THULE WILL NOTIFY ITS DEALERS AND CUSTOMERS AND WILL REPLACE THE DEFECTIVE BIKE RACKS FREE OF CHARGE. OWNER NOTIFICATION BEGAN SEPTEMBER 30, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REPLACEMENT BIKE RACK WITHIN A REASONABLE TIME SHOULD CONTACT THULE AT 800-848-5391.
EAST/FMVSS 121/CERTIFICATION LABEL
IF THAT INACCURATE INFORMATION IS RELIED UPON BY THE OWNER OF THE VEHICLE, THEN EXTRA WEIGHT LOADED ONTO A VEHICLE COULD AFFECT THE AIR BRAKE SYSTEM PERFORMANCE.
DEALERS WILL CORRECT THE CERTIFICATION LABEL. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING SEPTEMBER OR OCTOBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT EAST MANUFACTURING AT 1-330-325-9921.
VW/IGNITION SWITCH
IF SUCH FAILURES OCCUR WHILE THE VEHICLE IS IN USE AT NIGHT OR IN RAINY OR SNOWY WEATHER, A CRASH COULD OCCUR.
DEALERS WILL REPLACE THE ELECTRICAL PART OF THE IGNITION SWITCH ASSEMBLY. OWNER NOTIFICATION BEGAN NOVEMBER 20, 2002. OWNERS SHOULD CONTACT VWOA AT 1-800-822-8987.
DAEWOO/FMVSS 106/BRAKE HOSES
THIS CAN RESULT IN BRAKE HOSE RUPTURE, BRAKE FLUID LEAKAGE, AND LOSS OF VEHICLE BRAKING.
DEALERS WILL INSTALL NEW REDESIGNED FRONT BRAKE HOSES. OWNER NOTIFICATION BEGAN OCTOBER 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAEWOO AT 1-877-362-1234, SELECTION 1.